Oak Ridge Today

Council asks UPF project director to postpone removal of trees on top of Pine Ridge

Posted at
By Leave a Comment

A letter unanimously approved by Oak Ridge City Council on Monday, Nov. 13, 2017, asks federal officials to postpone a project to remove trees and other vegetation from the top of Pine Ridge, pictured above from South Illinois Avenue in south Oak Ridge, for 161-kilovolt power lines that will provide electricity to a new substation at the Y-12 National Security Complex. (Photo by John Huotari/Oak Ridge Today)

A letter unanimously approved by Oak Ridge City Council on Monday, Nov. 13, 2017, asks federal officials to postpone a project to remove trees and other vegetation from the top of Pine Ridge, pictured above from South Illinois Avenue in south Oak Ridge, for 161-kilovolt power lines that will provide electricity to a new substation at the Y-12 National Security Complex. (Photo by John Huotari/Oak Ridge Today)

 

A letter unanimously approved by Oak Ridge City Council on Monday asks federal officials to postpone a project to remove trees and other vegetation from the top of Pine Ridge for 161-kilovolt power lines that will provide electricity to a new substation at the Y-12 National Security Complex.

Among the City Council concerns: They only recently learned of the project, they don’t know what other options were considered, and they are worried about the visual impact of 79-foot transmission towers being located on top of Pine Ridge. Also, Council members said, there has been no public discussion about the project until two weeks before the logging operation was scheduled to start on Thursday, November 16.

The clearing work is part of a project to build a new substation at Y-12. It will replace an existing substation that is “nearing the end of its service life,” according to information presented to City Council and some community members. The tree removal will allow the 161-kilovolt power lines to be installed in the cleared area. The area to be cleared is on top of the ridge, about 2.1 miles long, and it will support a right-of-way that is about 100 feet wide. The electrical line would run from east to west on Pine Ridge, according to a report to City Council from Oak Ridge City Manager Mark Watson. All of the work would be on U.S. Department of Energy property, officials said.

The new substation will service all of Y-12, but it is being built as a subproject of the Uranium Processing Facility. It would be near UPF on the west side of Y-12. [Read more…]

Groundbreaking scheduled for Mercury Treatment Facility at Y-12

Posted at
By Leave a Comment

The planned Mercury Treatment Facility at the Y-12 National Security Complex in Oak Ridge. (Image courtesy UCOR/U.S. Department of Energy Oak Ridge Office of Environmental Management)

The planned Mercury Treatment Facility at the Y-12 National Security Complex in Oak Ridge. (Image courtesy UCOR/U.S. Department of Energy Oak Ridge Office of Environmental Management)

 

A groundbreaking has been scheduled for Monday morning for the Mercury Treatment Facility at the Y-12 National Security Complex.

Y-12 operations have historically used large amounts of mercury, and many of the buildings, now in varying states of deterioration, have mercury contamination, a media advisory said.

“The treatment facility will lower existing mercury levels from past releases and will serve as a guard against a potential increase in releases as mercury-contaminated buildings are demolished,” the media advisory said.

Deputy Energy Secretary Dan Brouillette will attend the groundbreaking, which is at Y-12 and not open to the public. U.S. Senator Lamar Alexander and U.S. Representative Chuck Fleischmann, both Tennessee Republicans, will also attend the groundbreaking, the media advisory said.

The groundbreaking is being presented by the U.S. Department of Energy and URS|CH2M Oak Ridge LLC, or UCOR, DOE’s cleanup contractor at federal sites in Oak Ridge. [Read more…]

With $3 billion in savings expected, not clear how much saved at Y-12, Pantex so far

Posted at
By Leave a Comment

Y-12 National Security Complex

The Y-12 National Security Complex in Oak Ridge is pictured above. (File photo/B&W Y-12)

 

More than $3 billion in savings are expected during a decade, but it’s not clear yet how much money has been saved after three years under a consolidated contract at two nuclear weapons plants in Tennessee and Texas.

The savings of $3.27 billion are expected under a contract that could last 10 years at the Y-12 National Security Complex in Oak Ridge, Tennessee, and Pantex Plant in Amarillo, Texas.

On Monday, officials said Consolidated Nuclear Security LLC, the contractor at the two sites, has generated significant savings in three fiscal years, although it’s not clear exactly how much they’ve saved. CNS has managed and operated Y-12 and Pantex Plant since July 1, 2014.

Federal officials announced the expected savings of $3.27 billion during a decade when the five-year contract was announced in January 2013. Officials said the consolidated contract, the result of years of work, could save money in part by eliminating redundancies in such areas as human resources, purchasing, finance, and information technology. [Read more…]

Y-12 Historian Ray Smith is retiring

Posted at
By Leave a Comment

Ray Smith, Y-12 National Security Complex historian and city historian, announces a book published posthumously that was written by Bill Wilcox, a former city historian, former technical director at K-25 and Y-12, and a passionate advocate for historic preservation, including the history of the former K-25 site. Smith announced the book at a ceremony unveiling plans for a K-25 History Center on the second floor of the city-owned fire station at the the former K-25 site, now known as East Tennessee Technology Park on Thursday, Oct. 19, 2017. (Photo by John Huotari/Oak Ridge Today)

Ray Smith is retiring as Y-12 National Security Complex historian on Nov. 22, 2017. Smith is pictured above during a ceremony for the K-25 History Center at East Tennessee Technology Park on Thursday, Oct. 19. (Photo by John Huotari/Oak Ridge Today)

 

Y-12 National Security Complex Historian Ray Smith is retiring. Smith said he has been at Y-12 for 47 years, and he is retiring November 22.

Besides being Y-12 historian, Smith is also City of Oak Ridge historian and history columnist for The Oak Ridger newspaper, where he writes “Historically Speaking.” In 2012, he testified during a U.S. House of Representatives hearing on the legislation to create the Manhattan Project National Historical Park, which includes Oak Ridge; Los Alamos, New Mexico; and Hanford, Washington.

Smith has been Y-12 historian for about 10 years. He has also been a maintenance manager at Y-12.

“I have thoroughly enjoyed it,” Smith said this week.

After an overseas trip in August, Smith said he wants to travel with his wife Fanny.

“Fanny and I went to Switzerland, Austria, and Germany, and that made my decision,” Smith said.

Smith, who is a Vietnam veteran, said he will continue to write and be the Oak Ridge historian. He is vice president of the Oak Ridge Heritage and Preservation Association, and he was recently appointed to the Tennessee Historical Commission. He is a local leader helping to preserve the city’s history. He was friends with Bill Wilcox, the previous city historian who wrote a history of the former K-25 site that has been published posthumously with help from family members, Smith, and the Oak Ridge Heritage and Preservation Association.

[Read more…]

Congressmen praise consolidated contract at Y-12, Pantex

Posted at
By 4 Comments

U.S. Representative Mac Thornberry, left, a Texas Republican, and Representative Chuck Fleischmann, a Tennessee Republican, are pictured above after an East Tennessee Economic Council meeting on Friday, Oct. 6, 2017. (Photo by John Huotari/Oak Ridge Today)

U.S. Representative Mac Thornberry, left, a Texas Republican, and Representative Chuck Fleischmann, a Tennessee Republican, are pictured above after an East Tennessee Economic Council meeting on Friday, Oct. 6, 2017. (Photo by John Huotari/Oak Ridge Today)

 

Two congressmen, one from East Tennessee and other the chair of the House Armed Services Committee, praised the consolidated contract that has been used to manage and operate the Pantex Plant in Amarillo, Texas, and the Y-12 National Security Complex in Oak Ridge for more than three years.

The two sites are managed by Consolidated Nuclear Security LLC. Y-12 and Pantex are involved in nuclear weapons work and nuclear nonproliferation, and providing enriched uranium for naval, research, and isotope production reactors.

The transition to the consolidated contract, one of the most complex in the history of the U.S. Department of Energy, was completed on July 1, 2014. At that time, officials said the contract included a total annual operating budget of $1.5 billion and employment of about 8,000 in Tennessee and Texas. [Read more…]

DOE, NNSA deny alleged risk of ‘catastrophic collapse’ of old Y-12 buildings

Posted at
By Leave a Comment

Y-12 Building 9212

A low-level aerial shot of Building 9212 at the Y-12 National Security Complex, one of the buildings mentioned in a federal lawsuit filed in July over the proposed Uranium Processing Facility.

 

Note: This story was updated at 8:30 a.m.

The plaintiffs in a civil lawsuit filed in federal court in July alleged that there is a risk of a catastrophic collapse of old buildings containing nuclear weapon components at the Y-12 National Security Complex, possibly due to a large earthquake. A catastrophic collapse “would likely” result in the release of nuclear or toxic materials and place the environment and local residents in “extreme peril,” the plaintiffs said.

But federal officials denied that allegation and others in a response filed in late September.

The 44-page civil complaint, which is related to the planned Uranium Processing Facility at Y-12, was filed July 20 in U.S. District Court in Washington, D.C. The seven plaintiffs include three public interest organizations—Oak Ridge Environmental Peace Alliance, Nuclear Watch of New Mexico, and Natural Resources Defense Council of Washington, D.C.—and four people who live in Oak Ridge and Knoxville.

The federal lawsuit asked for an environmental review of the new design for the UPF, where design plans have changed from one building to three. The lawsuit alleged that the U.S. Department of Energy and the National Nuclear Security Administration have violated a federal environmental law, the National Environmental Policy Act, or NEPA, as they implement the major design change.

Specifically, the plaintiffs have requested a new supplemental environmental impact statement or a new site-wide environmental impact statement for the revised UPF design. They cited the decision to build several new buildings and the plan to continue using existing buildings that the plaintiffs say have significant structural defects. They want the U.S. District Court to vacate, or void, a supplement analysis and an amended record of decision prepared by the NNSA in 2016. [Read more…]

DOE, NNSA computing project names new director, to be based at ORNL

Posted at
By Leave a Comment

Doug Kothe

Doug Kothe

A collaboration between the U.S. Department of Energy and the National Nuclear Security Administration has named a new director of the project to build computing systems that are at least 50 times faster than the nation’s most powerful supercomputers in use today—and the new director will be based at Oak Ridge National Laboratory.

The collaborative project is the Exascale Computing Project. It’s a collaboration between DOE’s Office of Science and the NNSA, which is a semi-autonomous agency within DOE.

The new director is Doug Kothe, a 32-year veteran of DOE’s national laboratory system who most recently served in ORNL’s Computing and Computational Sciences Directorate and as the applications development lead for the Exascale Computing Project, or ECP. For the preceding five years, he led the Consortium for Advanced Simulation of Light Water Reactors, DOE’s first Energy Innovation Hub, which uses supercomputers to improve nuclear reactor performance.

Kothe will be ECP director effective October 1. He will replace Paul Messina, who is stepping down after two years to return to Argonne National Laboratory, a press release said. [Read more…]

Y-12 saves more than $500,000 per year, receives energy management award

Posted at
By Leave a Comment

The Jack Case Center at the Y-12 National Security Complex. (Photo courtesy NNSA)

The Jack Case Center at the Y-12 National Security Complex. (Photo courtesy NNSA)

 

Award-winning energy efficiency upgrades at the Y-12 National Security Complex in Oak Ridge have saved more than $538,000 per year in energy expenses, according to the U.S. Department of Energy.

Y-12 has used energy savings performance contracts to enhance its building infrastructure, DOE said. That included a major project in fiscal year 2016 to modernize 11,450 lighting fixtures in 123 facilities. The upgrades improved lighting conditions in more than 1.5 million square feet of work space, reduced electricity use by 36 billion Btu (British thermal units) per year, and saved more than $538,000 annually in energy costs, DOE said.

“Y-12’s innovative lighting design included de-lamping efforts to eliminate unneeded lighting, and used reflectors and optimized light levels to improve security, safety, and productivity,” DOE said. “The installation team also developed an innovative, streamlined lock-out/tag-out procedure—a critical safety step that normally can add significant amounts of time to a project of this size—and installed quick-connects on individual fixtures that allowed each fixture to be disconnected from power at the fixture location. These innovations enabled completion of the project two months ahead of schedule, with savings estimated in the hundreds of thousands of dollars due to reduced future preventive maintenance during re-lamping and ballast replacements.” [Read more…]

Y-12 has emergency management exercise on Wednesday

Posted at
By Leave a Comment

The sign at the main entrance to the Y-12 National Security Complex is pictured above on Sunday, Aug. 6, 2017. (Photo by John Huotari/Oak Ridge Today)

The sign at the main entrance to the Y-12 National Security Complex is pictured above on Sunday, Aug. 6, 2017. (Photo by John Huotari/Oak Ridge Today)

 

Emergency response personnel from the National Nuclear Security Administration and Consolidated Nuclear Security—along with federal, state, and local emergency management personnel—will conduct an emergency management exercise Wednesday, September 20, in and around the Y‑12 National Security Complex.

During this exercise, people near Y-12 may observe police and other emergency response vehicles, as well as responders simulating activities, a press release said. These activities are part of the exercise, the release said.

This event is one of several emergency management exercises conducted on a regular basis at the U.S. Department of Energy/National Nuclear Security Administration facilities in Oak Ridge. These exercises test the ability of emergency personnel to respond quickly and effectively to emergency situations and ensure that the public, Y-12 employees, and the environment would be protected in the event of an actual emergency occurring on the Oak Ridge Reservation, the press release said.

Consolidated Nuclear Security LLC operates the Pantex Plant, located in Amarillo, Texas, and the Y-12 National Security Complex, located in Oak Ridge, Tennessee, under a single contract for the U.S. National Nuclear Security Administration.

CNS names four to Fellows Program, recognizing technical expertise

Posted at
By Leave a Comment

Consolidated Nuclear Security LLC has chosen four employees for its Fellows Program, one from the Pantex Plant in Amarillo, Texas, and three from the Y-12 National Security Complex in Oak Ridge. They are Vincent Lamberti, top left; Alan Moore, top right; and Glenn Pfennigwerth, bottom left, all of Y-12, and Lorelei Woods of Pantex. (Submitted photos)

Consolidated Nuclear Security LLC has chosen four employees for its Fellows Program, one from the Pantex Plant in Amarillo, Texas, and three from the Y-12 National Security Complex in Oak Ridge. They are Vincent Lamberti, top left; Alan Moore, top right; and Glenn Pfennigwerth, bottom left, all of Y-12, and Lorelei Woods of Pantex. (Submitted photos)

 

Consolidated Nuclear Security LLC has chosen four employees for its Fellows Program, one from the Pantex Plant in Amarillo, Texas, and three from the Y-12 National Security Complex in Oak Ridge.

The program recognizes technical staff members at Pantex and Y-12 who achieved status as a national or international expert in their field, a press release said. Each fellow serves a renewable two-year term acting as the technical expert in their competency area and mentor to other staff.

Those chosen are Pantex Component Analysis/Surveillance Fellow Lorelei Woods, Uranium Fellow Glenn Pfennigwerth, Metallurgy Fellow Alan Moore, and Y-12 Component Analysis/Surveillance Fellow Vincent Lamberti. [Read more…]

Consolidated Nuclear Security gives, receives recognitions at inaugural award ceremony

Posted at
By Leave a Comment

Jorge and Deana Sanabria, owners of Expoquip Inc., accept the CNS Small Business of the Year award from Y-12 Socioeconomic Program Manager Lisa Copeland, left. (Photo courtesy CNS)

Jorge and Deana Sanabria, owners of Expoquip Inc., accept the CNS Small Business of the Year award from Y-12 Socioeconomic Program Manager Lisa Copeland, left. (Photo courtesy CNS)

 

As part of the first combined ceremony honoring outstanding small business and local business leaders, Consolidated Nuclear Security LLC honored its Small Business of the Year, and CNS President and Chief Executive Officer Morgan Smith was recognized with the Kerry Trammell Volunteer of the Year award.

This is the first year CNS, the Oak Ridge National Laboratory, and the Oak Ridge Chamber of Commerce have combined their award ceremonies, a press release said.

Expoquip Inc. was recognized as the CNS Small Business of the Year. The company, owned by Jorge and Deana Sanabria, specializes in worldwide distribution of high-quality, heavy machinery parts, and components, the press release said.

“Expoquip has the characteristics I look for in a vendor: passion, commitment, drive,” said Lisa Copeland, Y-12 socioeconomic program manager. “From the time I met them at a local supplier event in 2013, I knew they would achieve their dream of expanding their business by moving into government subcontracting. You just don’t encounter many business owners with the enthusiasm and determination that the Sanabrias show.” [Read more…]

Peace activists will remember Hiroshima, Nagasaki bombings, call for ban on nuclear weapons

Posted at
By Leave a Comment

OREPA-Ralph-Hutchison-Aug-6-2016-2

Ralph Hutchison, coordinator of the Oak Ridge Environmental Peace Alliance, is pictured above during a rally at Alvin K. Bissell Park on Saturday, Aug. 6, 2016. (File photo by John Huotari/Oak Ridge Today)

 

Peace activists will have events in Oak Ridge and Knoxville starting Saturday and ending Wednesday that will recall the atomic bombings of Hiroshima and Nagasaki, Japan, during World War II, and the activists will call for a ban on nuclear weapons.

The events have been organized by the Oak Ridge Environmental Peace Alliance. OREPA has events each August remembering the bombings of Hiroshima and Nagasaki near the end of World War II. The Y-12 National Security Complex in Oak Ridge enriched uranium for the first atomic bomb used in wartime. Code-named “Little Boy,” the bomb was dropped over Hiroshima, Japan, on August 6, 1945, shortly before the end of the war.

OREPA has scheduled a Saturday event called “And We Are Saying Peace.” It will start at 12:30 p.m. with a concert and theater presentation at Alvin K. Bissell Park in Oak Ridge. Those who attend will call on the United States to join the countries that passed a legal treaty prohibiting nuclear weapons at the United Nations on July 7, a press release said.

The Saturday event will also mark the conclusion of a peace pilgrimage from Asheville, North Carolina, to Oak Ridge, led by the Buddhist order Nipponzan Myohoji, the press release said. The walk left Asheville last Sunday and is expected to arrive at Bissell Park on Saturday. The final leg will leave Solway at 9 a.m. Saturday. [Read more…]