Oak Ridge Today

Field work complete, cleanup projects used $751 million in Recovery Act funding

Posted at
By Leave a Comment

Building K-33

Building K-33 at the East Tennessee Technology Park, also known as the former K-25 site, before demolition. (DOE photo)

 

Note: This story was updated at 5:30 p.m.

The field work is complete on 27 cleanup projects at three federal sites in Oak Ridge that used $751 million in Recovery Act funds.

The U.S. Department of Energy’s Oak Ridge Office of Environmental Management, or EM, announced the end of the field work on Thursday.

“We’re done knocking down buildings and with all the work in the field,” said Mike Koentop, executive officer in Oak Ridge Office of Environmental Management. “We have paperwork left to do to close out projects.”

The American Recovery and Reinvestment Act of 2009, also known as the Recovery Act or stimulus bill, was passed by Congress and signed by President Barack Obama in February 2009. It was meant to help stimulate an economic recovery during the depths of the Great Recession, and it was intended to address long-neglected infrastructure projects and programs.

In Oak Ridge, the Recovery Act funding paid for several demolition projects such as the demolition of the 1.4-million-square-foot K-33 Building at the East Tennessee Technology Park and other projects ranging from mercury reduction at the Y-12 National Security Complex to transuranic waste processing at Oak Ridge National Laboratory. [Read more…]

Splitting UPF project into two buildings could save money, senator says

Posted at
By Leave a Comment

U.S. Senator Lamar Alexander

Lamar Alexander

Money could be saved on the new Uranium Processing Facility at the Y-12 National Security Complex by splitting up the project into two buildings rather than one, U.S. Sen. Lamar Alexander said during a congressional hearing in Washington, D.C., on Wednesday.

One building could be used for high-security work, Alexander said during a hearing of the Energy and Water Development Subcommittee. That high-security building would cost several times as much as a second building used for low-security work, Alexander said.

Not all of the work has to be conducted in a high-security facility, the Tennessee Republican said, and some of it could be conducted in the low-security building.

It wasn’t immediately clear if the two-building proposal is included in a so-called Red Team Review of the UPF project. That report could be made public this week. Federal officials and members of Congress have already been briefed on it. [Read more…]

Y-12, Pantex workforce reductions could total about 170 jobs

Posted at
By Leave a Comment

Y-12 National Security Complex Scarboro Road Entrance

The Scarboro Road entrance to the Y-12 National Security Complex is pictured above.

Workforce reductions at the Y-12 National Security Complex in Oak Ridge and Pantex Plant in Amarillo, Texas, are expected to total about 170 jobs, officials said this week.

That’s about 2 percent of the roughly 7,900 workers at the two nuclear weapons plants.

The workforce reductions are expected to come through a voluntary separation program, or VSP.

The majority of the reductions, or 140 positions, would be at Y-12. The other 30 would be at Pantex.

The VSPs are being considered as a new federal contractor, Consolidated Nuclear Security LLC, prepares to take over at Y-12 and Pantex on July 1. CNS, which was first announced as the new consolidated contractor in January 2013, has promised to save the federal government more than $3 billion during the next decade. [Read more…]

Mason to brief feds on UPF alternatives report today

Posted at
By Leave a Comment

Ernest Moniz, Lamar Alexander, Thom Mason, Joe DiPietro, Jimmy Cheek at University of Tennessee

From left are UT President Joe DiPietro, Chancellor Jimmy Cheek, Energy Secretary Ernest Moniz, U.S. Sen. Lamar Alexander, and ORNL Director Thom Mason.

Note: This story was last updated at 2:30 p.m.

KNOXVILLE—Federal officials have expressed concerns about increasing cost projections and delayed construction dates for a new Uranium Processing Facility at the Y-12 National Security Complex, and a so-called Red Team has drafted an alternative approach that could keep the project at $6.5 billion or less—and help workers get out of the aging Building 9212 at Y-12 by 2025.

Thom Mason, the director of Oak Ridge National Laboratory, chaired the Red Team, and he is expected to brief federal officials in Washington, D.C., today (Monday) on the team’s report. The report will then go to Congress, Energy Secretary Ernest Moniz said in a media briefing at the Howard H. Baker Jr. Center at the University of Tennessee on Friday.

Among the questions that could be answered are which old production buildings at Y-12 should be replaced and which can be refurbished. Y-12 was built to enrich uranium as part of the top-secret Manhattan Project during World War II as the United States raced to beat Germany to build the world’s first atomic weapons. [Read more…]

Staff size at Y-12, Pantex could be reduced through voluntary separations

Posted at
By Leave a Comment

Y-12 National Security Complex Aerial View

The Y-12 National Security Complex is pictured above.

The staff size at the Y-12 National Security Complex in Oak Ridge and Pantex Plant in Amarillo, Texas, could be reduced as a new federal contractor takes over. Officials expect the staff reductions to be less than 5 percent, and they say that most, if not all, of the staff reductions could come through voluntary separation programs.

The voluntary separation programs, or VSPs, were announced on April 15 by B&W Y-12 President and General Manager Dave Richardson and B&W Pantex President and General Manager John Woolery.

In his message to Y-12 workers, Richardson said the National Nuclear Security Administration had directed the plants to conduct the VSPs as part of the implementation of the staffing plan for Consolidated Nuclear Security LLC, the new contractor at the two nuclear weapons plants in Tennessee and Texas.

The Y-12 VSP will be targeted to specific job classifications and roles identified by CNS, Richardson said. Only employees in those specific classifications and roles will be eligible to apply for the VSP.

“Currently, B&W Y-12 is in the process of putting together a VSP plan that is in alignment with CNS’ staffing desires,” Richardson said last week. “We will submit our VSP plan later this week. Once this plan is approved by NNSA, we’ll communicate more details to you; specifically, each person eligible to participate in the VSP will be notified.” [Read more…]

No one injured when part of concrete ceiling falls in Y-12 building

Posted at
By Leave a Comment

Y-12 National Security Complex Sign

No one was injured when chunks of concrete weighing up to 20 pounds fell from the ceiling in a roped-off area in a building at the Y-12 National Security Complex in March.

No one was injured when chunks of concrete weighing up to 20 pounds fell from the ceiling in a roped-off area in a building at the Y-12 National Security Complex in March.

That area of Building 9204-2 in Y-12‘s production area had been roped off to restrict worker access. The controlled area has been in place since 2009, said B&W Y-12, the plant’s managing and operating contractor. Access to the area was controlled with marker tape and boundary markers.

When the ceiling fell in that part of the building, large chunks of concrete rebounded into a frequently used walkway and an adjacent welding station, the Defense Nuclear Facilities Safety Board reported in the week ending March 21. Workers had used the welding station earlier in the day, the DNFSB said.

B&W Y-12 said chunks of the concrete fell to the floor and struck a portable welding exhaust unit located inside the controlled area. Some small pieces of the concrete also scattered outside of the area. Personnel in a nearby area heard the noise, discovered the problem, and immediately notified the shift manager, per procedures, the contractor said. [Read more…]

Review team develops UPF alternative, sends report to NNSA

Posted at
By Leave a Comment

Thom Mason

Thom Mason

The projected cost had passed $10 billion and the completion date pushed back to 2038, so federal officials were looking for an alternative approach for the proposed Uranium Processing Facility at the Y-12 National Security Complex.

Earlier this year, the National Nuclear Security Administration asked Thom Mason, Oak Ridge National Laboratory director, to lead a team—a so-called “Red Team”—that would develop an alternative approach.

The team’s task was to find a faster, more efficient solution, NNSA Acting Administrator Bruce Held told a House subcommittee on April 3.

On Tuesday, the deadline for submitting a report, Mason said the team has identified a possible alternative and provided information on how the proposal could be implemented if the NNSA adopts it. The next step will be up to the NNSA. Y-12 is an NNSA site.

The goal is to still allow workers to get out of Y-12’s aging Building 9212 by 2025 and keep the cost within an approved range of $4.2 billion to $6.5 billion, Mason said late Tuesday afternoon, when the report was being polished before transmittal. [Read more…]

Alexander: Red Team Review of UPF could be model for other DOE projects

Posted at
By Leave a Comment

Uranium Processing Facility

Pictured above is the proposed Uranium Processing Facility at Y-12 National Security Complex, with the administrative area in the front and the fortified section of the building in the rear. (Submitted image)

U.S. Sen. Lamar Alexander on Wednesday called for a special Senate hearing on whether an ongoing review of the Uranium Processing Facility in Oak Ridge could serve as a model to improve oversight of U.S. Department of Energy projects, a press release said.

In a hearing held by the Appropriations Subcommittee for Energy and Water Development, of which he is the lead Republican, Alexander noted that Thom Mason, director of Oak Ridge National Laboratory, is currently conducting a “Red Team” review of UPF. Mason’s Red Team members are using the same process that has made the Office of Science the only office in DOE that successfully manages efficient and cost-effective projects, said Alexander, a Tennessee Republican. [Read more…]

Y-12 security project completed $20M under budget, ahead of schedule

Posted at
By Leave a Comment

Y-12 National Security Complex Scarboro Road Entrance

The Scarboro Road entrance to the Y-12 National Security Complex is pictured above.

A security improvement project at the Y-12 National Security Complex was completed ahead of schedule and about $20 million under budget, federal officials announced Monday.

The National Nuclear Security Administration’s Security Improvement Project upgraded security at Y-12 by replacing existing alarm stations and access control systems with Argus, a comprehensive security system developed by Lawrence Livermore National Laboratory, a press release said. The SIP came in about $20 million under the original $72 million budget.

“Maintaining a safe and secure deterrent is one of NNSA’s most important responsibilities,” said NNSA Acting Chief of Defense Nuclear Security Michael Lempke. “SIP is a continuation of NNSA’s goal to use the best, most modern security technology to keep the nation’s nuclear weapons and material secure.” [Read more…]

CNS announces org chart, senior leaders for Y-12, Pantex

Posted at
By Leave a Comment

Y-12 National Security Complex Aerial View

The Y-12 National Security Complex is pictured above.

The new federal contractor at the Y-12 National Security Complex in Oak Ridge and Pantex Plant in Amarillo, Texas, has started announcing members of its senior leadership team.

Jim Haynes, chief executive officer for Consolidated Nuclear Security LLC, announced the leaders in a message posted on the company’s transition website on Saturday.

The executives are:

  • Jim Allen—chief operating officer
  • Darrell Graddy—senior vice president for mission support
  • Ken Freeman—senior vice president for safeguards, security, and emergency services
  • Rick Glass—senior vice president for mission assurance

“We will roll out our senior leadership team in phases, and over the next few weeks we will help you get to know the CNS leadership team through a series of articles, employee information meetings in Amarillo and Oak Ridge, and other opportunities for face-to-face interaction,” Haynes said. [Read more…]

B&W restructures government ops; former Y-12 manager the COO of one group

Posted at
By Leave a Comment

Chuck Spencer

Chuck Spencer

CHARLOTTE, N.C.—The Babcock and Wilcox Co. has announced a restructuring of its government operations.

Effective immediately, the Babcock and Wilcox Nuclear Operations Group Inc., or NOG, its subsidiary operations at Nuclear Fuel Services, and the Babcock and Wilcox Technical Services Group Inc., or TSG, will operate under a single leader, naming Peyton S. “Sandy” Baker as president and chief operating officer, a press release said.

Charles G. “Chuck” Spencer, the former president and general manager of the Y-12 National Security Complex, will serve as chief operating officer of TSG, leading the business’ day-to-day operations, a press release said.

And Kenneth R. Camplin has been named vice president and chief business development officer for B&W’s government operations. Camplin and Spencer will both report to Baker, the release said. [Read more…]

Spotlight: Eight Y-12 employees awarded master’s in engineering management

Posted at
By Leave a Comment

Y-12 National Security Complex Aerial View

Eight employees at the Y‑12 National Security Complex, pictured above, recently earned a master’s in industrial engineering with a concentration in engineering management at the University of Tennessee in Knoxville.

Eight employees at the Y‑12 National Security Complex recently earned a master’s in industrial engineering with a concentration in engineering management at the University of Tennessee in Knoxville.

Students pursuing this degree complete the 16-course, four-semester program as an ensemble, attending all-day Friday classes not held on the university campus.

“This particular program is one of the success stories of the Y‑12/University of Tennessee Partnership,” reported Debbie Reed, Y‑12’s UT liaison director. “But setting up the program was the easy part. Being a nontraditional student isn’t easy. Anyone who works full-time and still has the discipline and drive to take on college studies deserves special recognition. Putting in a 4/10 workweek and then taking another full day of classes—along with doing the homework that comes with those classes—that’s a lot of extra effort.” [Read more…]